Often asked: How To Replace A Thermostat On An Electric Water Heater?

How do I know if my hot water heater thermostat is bad?

If you turn the hot water tap and cold water runs out, then the upper thermostat is damaged. But if the water is hot that becomes later becomes cold, then you have a damaged lower thermostat.

Do you have to drain a hot water heater to change the thermostat?

Always disconnect the power or shut off the breaker before doing any work on a water heater. To change thermostats, you will need to remove the access panel and safety cover (do this for both upper and lower access panels on dual element units).

How much does it cost to replace an electric water heater thermostat?

The average thermostat replacement cost is between $100 and $300. Most other repairs are equally affordable. There are two main types: gas and electric. A gas unit works by way of a gas flame while an electric one works using electric elements, or coils.

You might be interested:  Often asked: What Is The Best Water Heater On The Market?

Can a thermostat go bad on a hot water heater?

Usually, when the upper thermostat goes bad, you will have no hot water at all, while a bad lower thermostat makes itself known when there is only a small amount of hot water before the tap water goes cold. Once you have determined the faulty thermostat, you can replace it and have your hot water heater working again.

How do you reset a thermostat on a hot water heater?

Somewhere on your electric water heater, you’ll find a reset button. It’s usually red and often located near the thermostat. It may also be hidden behind a removable metal panel on the unit—and then behind some insulation. Once you find the button, push and release it.

What trips the reset button on a hot water heater?

The reset button: a red button located on the water heater itself (just above the thermostat) that trips when the water temperature exceeds 180 F. The reset button is sometimes referred to as the “ECO” (emergency cut off) or “high limit switch”.

Where is the thermostat located on an electric hot water heater?

Electric water heaters often have two thermostats — one at the top and another at the bottom of the tank. And most tankless water heaters feature a display with a temperature readout and controls for adjusting the temperature.

What causes a water heater thermostat to burn up?

Usually the cause of overheated water is a lower heating element that has a leak to ground. You need to turn power off to the heater. Disconnect both wires to both elements.

You might be interested:  Readers ask: How To Replace 98 Camry Heater Core?

How do you troubleshoot an electric water heater?

First, reset any tripped circuit breaker, and replace any blown fuse. Next, check if power is being supplied to the electric water heating element thermostat. Test the element, and if it’s faulty, replace it.

Are electric water heater thermostats universal?

There are more than 50 brands of residential tank type electric water heaters in the U.S., most thermostats are interchangeable, however, read the product description carefully. If you must replace a thermostat its always a good idea to replace both thermostats at the same time.

How do I test my thermostat?

Raise the thermostat heat settings slowly. The thermostat should emit a clicking sound and the furnace should also make a sound. If the furnace does not make a sound, the thermostat is not sending a signal and needs to be replaced. Turn off the breaker to your furnace.

What is the most common problem with water heaters?

A water tank that produces too little hot water is one of the many common water heater problems you may encounter. Usually this can be solved by turning up the temperature on the tank’s thermostat. Be careful, however, not to turn the temperature up too high, as this can be a scalding hazard. No hot water.

What is the lifespan of a water heater?

Based on the manufacturer’s suggested service life, the life expectancy of a water heater is about eight to 12 years. That varies with the location and design of the unit, quality of installation, maintenance schedule and water quality.

How often should you change water heater?

How long should a hot water heater last? Many homeowners wonder “How often should a hot water heater be replaced?” In a typical situation, you should expect your water heater to last about ten years.

Leave a Reply

Your email address will not be published. Required fields are marked *