Often asked: Why Does My Heater Only Work On High?

Why does my heat only work on the highest setting?

If your heater only blows when the setting is on high, this may suggest that you have a faulty blower motor resistor. The highest speed setting may still work because in most cars in the highest fan speed settings the current bypasses the blower motor resistor.

How much does it cost to replace a blower resistor?

Blower Motor Resistor Replacement Cost – RepairPal Estimate. Labor costs are estimated between $44 and $55 while parts are priced between $64 and $82. This range does not include taxes and fees, and does not factor in your specific vehicle or unique location.

What makes a blower motor resistor go bad?

In most cases, a blower motor resistor fails due to corrosion or overheating. Sometimes, the mechanical resistance to the motor rotation causes an excessive electric current that can overheat and prematurely damage the blower motor resistor.

You might be interested:  FAQ: What Happens When Water Heater Breaks?

Where is the heater blower motor resistor?

The heater blower motor resistor is located underneath the dashboard in the heater/AC compartment. The resistor enables the heater blower motor to change the speed of the fan. Without this part you will not be able to change the speed of the airflow from the blower motor.

How much does it cost to replace a blower motor?

Cost to Replace Central or Forced Air Blower Motor Replacing a blower motor costs $450 on average with a typical range of $250 to $800. With a warranty, you might pay as little as $150 for labor alone. For high-end models, like those with large motors or access issues, you might pay as much as $2,000.

What are the symptoms of a bad blower motor?

Here are just a few of the signs that your blower motor is going bad.

  • Weak airflow. This is one of the first signs of a bad blower motor that people tend to notice.
  • Noises. Have you noticed any unusual noises coming from your vehicle’s HVAC system?
  • Smoke or smells.

What causes heater resistors to burn out?

Trent, one of the biggest reasons for blower motor resistors to have shorten life is actually because of faulty blower motor drawing too many amps, some times melting wires/plugs, heating up resistors shortening their life.

How do you test a blower motor resistor?

Blower Motor Resistor Testing Place one lead of the Ohmmeter on terminal 1 of the resistor. Place the other lead on terminal 2 and check against specifications. If this circuit is open, showing infinity on the Ohmmeter, the blower resistor must be replaced.

You might be interested:  Question: What Is A Good Temperature To Keep Your Heater At?

How do you know if you have a bad blower motor resistor?

Symptoms of a bad heater blower motor resistor

  1. Fan does not work at all, so no air comes out of the vents.
  2. Fan only works on some speeds and not others.
  3. Fan only works on the highest speed.
  4. Fan runs all the time and can’t be controlled with the fan switch.
  5. You see smoke coming out of the vents.

How long does it take to replace a blower motor resistor?

takes about 45 minutes.

Can you fix a blower resistor?

The resistor module is easy and inexpensive to replace. It’s then typically installed in the ductwork, near the car blower—either under the dash or under the hood. (Refer to a service manual to locate yours.) Purchase a new resistor module at the auto parts store (usually less than $25).

What does a bad blower motor sound like?

A defective blower motor will make a continuous sound noticeable by the passengers in the vehicle. It can manifest as a knocking, whirring, clunking, vibrating, squealing, or whining noise that persists until the blower motor is replaced.

Is there a fuse for blower motor?

The blower motor is powered by a fuse-like device called a relay. If your heater or air conditioner does not blow air through the vents, this could indicate that the blower motor fuse has probably blown. While replacement is easy, the exact location of your blower motor fuse may vary from vehicle to vehicle.

Leave a Reply

Your email address will not be published. Required fields are marked *